Product ID:FOSTER 30-25 (VAPOROUS MASTIC)
MSDS Date:02/10/1993
FSC:8030
NIIN:00-174-2588
MSDS Number: CBTLS

FOSTER PRODUCTS, CORP.

3900 JACKSON ST. NE
MINNEAPOLIS, MN 55421
US

Emergency Phone: 800-228-5635 EX 018/800-424-9300

Info Phone: 612-781-8071/FAX 612-782-1755

Cage: KO427

FOSTER PRODUCTS, CORP.

MINNEAPOLIS, MN 55421 US

Telephone: 612-781-8071/FAX 612-782-1755

Cage: KO427

CHLORINATED PARAFFIN (SARA 313)(VP NIL @ 20C)

CAS: 63449-39-8

RTECS: RV0480000

Fraction By Weight: 5-10%

VOC = 444 G/L MATERIAL LESS WATER & EXEMPT SOLVENTS

RTECS: 9999999VO

OSHA PEL NOT RELEVANT

ACGIH TLV: NOT RELEVANT

STODDARD SOLVENT (VP = 2 @ 20C)

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: 30-50%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

ALUMINUM OXIDE (SARA 313)

CAS: 1344-28-1

RTECS: BD1200000

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

CALCIUM SILICATE

CAS: 1344-95-2

RTECS: VV9150000

OSHA PEL 15 MG/M3TDUST/RESP 5

ACGIH TLV: 10 MG/M3 TDUST

ANTIMONY TRIOXIDE (SARA 313) (CERCLA)

CAS: 1309-64-4

RTECS: CC5650000

OSHA PEL 0.5 MG (SB)/M3

ACGIH TLV: 0.5 MG (SB)/M3; 9495

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

TALC (CONTAINING NO ASBESTOS)

CAS: 14807-96-6

RTECS: MW2700000

OSHA PEL 15 MG/M3TDUST/RESP 5

ACGIH TLV: 10 MG/M3TDUST

TITANIUM DIOXIDE

CAS: 13463-67-7

RTECS: XR2275000

OSHA PEL 10 MG/M3TDUST/RESP 5

ACGIH TLV: 10 MG/M3TDUST

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES: CONTACT W/PROD/HIGH VAPOR LEVEL
CAUSES IRRIT.LIQ CONTACT DRIES/DEFATS SKIN.CHRONIC CONTACT MAY
CAUSE IRRIT/SENSITIZATION.INHAL: OVEREXPOSURE TO VAPORS CAUSE IRRIT
TO NOSE/THROAT/RESP TRACT.MAY C AUSE
DIZZINESS/HEADACHE/NAUSEA/UNCONSCIOUSNESS.INGEST: HARMFUL. CHRONIC:
LONG-TERM OVEREXPOSURE TO SOLVENTS MAY CAUSE*
Explanation of Carcinogenicity:CHLORINATED PARAFFIN/ANTIMONY TRIOXIDE
DUST ARE POSSIBLE CARCINOGENS.
Effects of Overexposure:NK *LIVER/KIDNEY DAMAGE. IF PRODUCT SANDED
AFTER IN FINAL FORM, DUSTING/EXPOSURE COULD OCCUR.
Medical Cond Aggravated by Exposure:NO KNOWN EFFECTS ON OTHER
ILLNESSES.

First Aid:EYE: FLUSH IMMEDIATELY W/LARGE AMOUNTS WATER 15 MINUTES. CALL
DR. SKIN: WASH AFFECTED AREA W/SOAP & WATER. INHALATION: REMOVE
FROM EXPOSURE. RESTORE BREATHING IF NECESSARY. KEEP WARM/QUIET.
CALL DR. I NGESTION: IF PERSON CAN SWALLOW GIVE 1 GLASS WATER/MILK.
DON'T INDUCE VOMITING. GET IMMEDIATE MEDICAL AID. NEVER GIVE
ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.

Flash Point Method:SCC
Flash Point:105F,41C
Autoignition Temp:Autoignition Temp Text:NE
Lower Limits:NOT EST.
Upper Limits:NOT EST.
Extinguishing Media:WATER SPRAY, FOAM, DRY CHEMICAL, CO2.
Fire Fighting Procedures:PERSONS EXPOSED TO PRODUCTS OF COMBUSTION
SHOULD WEAR SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE
EQUIPMENT.
Unusual Fire/Explosion Hazard:THERE IS THE POSSIBILITY OF PRESSURE
BUILDUP IN CLOSED CONTAINERS WHEN HEATED. WATER SPRAY MAY BE USED
TO COOL THE CONTAINERS.

Spill Release Procedures:REMOVE ALL IGNIT SOURCES. VENTILATE AREA.
AVOID BREATHING VAPORS. DIKE/CONTAIN SPILL W/INERT ABSORBENT,
TRANSFER TO CONTAINER FOR DISPOSAL. USE NONSPARKING TOOLS. KEEP
SPILL OUT OF SEWERS.

Handling and Storage Precautions:GROUND DRUMS WHEN POURING. KEEP AWAY
FROM HEAT/SPARKS/FLAME. KEEP CONTAINER CLOSED. AVOID BREATHING
VAPORS. USE ONLY WITH ADEQUATE VENTILATION.
Other Precautions:AVOID CONTACT W/EYES, SKIN, CLOTHES. WASH THOROUGHLY
AFTER HANDLING. EMPTIED CONTAINER RETAINS VAPOR/PRODUCT RESIDUE.
OBSERVE ALL LABEL PRECAUTIONS UNTIL CONTAINER IS CLEANED. DON'T CUT
OR WELD ON/NEA R CONTAINER.

Respiratory Protection:USE NIOSH/MSHA APPROVED EQUIPMENT. ORGANIC VAPOR
RESPIRATORS WHEN AIRBORNE EXPOSURE LIMITS ARE EXCEEDED.
Ventilation:LOCAL EXHAUST PREFERRED. PROVIDE VENT TO CONTROL
CONTAMINANT LEVELS BELOW AIRBORNE EXPOSURE LIMITS.
Protective Gloves:RUBBER GLOVES
Eye Protection:WEAR SAFETY GLASSES, CHEM SAFETY GOGGLES
Other Protective Equipment:HAVE EYE WASHES AVAILABLE WHERE EYE CONTACT
CAN OCCUR. PREVENT PROLONGED/REPEATED CONTACT W/PROTECTIVE
CLOTHING.
Work Hygienic Practices:LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
NK

Boiling Pt:B.P. Text:>200F,>93C
Melt/Freeze Pt:M.P/F.P Text:NA
Vapor Pres:NOT EST.
Vapor Density:NOT EST.
Spec Gravity:1.18
pH:NA
Evaporation Rate & Reference:NOT EST.
Appearance and Odor:LIQUID, CHARACTERISTIC COLOR, PUNGENT SOLVENT ODOR

Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:HYDROGEN CHLORIDE & PHOSGENE.
INCOMPLETE COMBUSTION CAN YIELD LOW MOLLECULAR WEIGHT HYDROCARBONS,
CARBON MONOXIDE.

Waste Disposal Methods:HAZARDOUS WASTE PER 40 CFR 261, IGNITABLE WASTE
CLASS D001. DISPOSAL BY INCINERATION RECOMMENDED. CONSULT LOCAL,
STATE,FEDERAL AUTHORITIES FOR MORE RESTRICTIVE REQUIREMENTS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.